S197 TSB list
 

Technical Service Bulletins
2005 MUSTANG


05-10-19
INTERMITTENT CD PLAYER CONCERNS - AUDIO UNIT PROGRAMMABLE MODULE INSTALLATION (PMI) REQUIREMENTS

05-9-18
DISCHARGED BATTERY - CHARGING SERVICE TIPS

05-9-15
MIL AND ETC LAMPS ON WITH BOTH DTC P2106 AND P2135 - VEHICLES BUILT 11/29/2004 AND PRIOR

05-9-14
CONVERTIBLE TOP RAISE/LOWER INSTRUCTIONS

05-9-11
FRONT SUSPENSION POPPING NOISE WHILE TURNING RIGHT OR LEFT - VEHICLES BUILT BEFORE 4/8/2005

05-9-3
INTERIOR PLASTIC TRIM - PAINT-TO-MATCH AND REPAIR - INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

05-8-8
GROWL/GRINDING NOISE IN 2ND OR 3RD GEAR DURING DECELERATION - TR3650 MANUAL TRANSMISSION - VEHICLES BUILT BEFORE 1/15/2005

05-8-6
EXHAUST VIBRATION AT 850 RPM - 4.0L ENGINE AND AUTOMATIC TRANSMISSION

05-7-3
AXLE WHINE - VEHICLES BUILT THROUGH 11/15/2004

05-6-15
AIR BAG WARNING LAMP ON - DTC B1891 IN RESTRAINTS CONTROL MODULE OR LAMP FLASHES CODE 53 - VEHICLES BUILT BEFORE 10/02/2004

05-4-8
FUEL FILL SLOW, OR DIFFICULT TO FILL

05-3-1
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)

04-26-22
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH MULTIPLE DIAGNOSTIC TROUBLE CODES (DTCS) P035X AND NO DRIVEABILITY SYMPTOMS - 4.6L 3V ENGINE

04-26-16
WELD BONDING PROCEDURE

04-24-20
LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS

04-24-14
GENERAL PCM PROGRAMMING PROCEDURES

04-24-5
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR

04-16-1
ENGINE MISFIRE OR ROUGH RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS

04-14-7
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS

04-9-6
BODY - PAINT - IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT - ACID RAIN NEUTRALIZATION

06-14-3
AIR CONDITIONER COMPRESSOR CLUTCH FAILURE - REVISED COMPRESSOR CLUTCH

06-12-11
LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS

06-10-13
MIL P0463 OR ERRATIC FUEL GAUGE

06-10-10
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

06-10-1
AIR CONDITIONER COMPRESSOR CLUTCH FAILURE - REVISED COMPRESSOR CLUTCH

06-9-9
HESITATION ON ACCELERATION AFTER LONG CRUISE

06-7-10
MIL ON WITH DTC P2004 THROUGH P2008, P151A, P2015, P2020 - 4.6L 3V

06-5-4
PARK BRAKE CABLE FREEZING/REAR BRAKES DRAGGING

06-4-9
A/C COMPRESSOR NOT OPERATIONAL / LOW FREON - SHAFT SEAL LEAKS

06-4-7
TICKING AND/OR KNOCKING NOISE FROM ENGINE - 4.6L/5.4L 3V

06-4-2
BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS

06-4-1
RATTLE/NOISE FROM THE CENTER STACK (RADIO/HEATER) OF THE INSTRUMENT PANEL OR GEARSHIFT AREA

06-3-13
FUEL FILL SLOW, OR DIFFICULT TO FILL

06-2-9
DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V

05-24-6
CONVERTIBLE SYSTEM CONCERNS

05-22-8
WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING

05-21-2
LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS

05-20-2
REAR AXLE NOISE
05-19-10
LOOSE SEAT CUSHION COVER TRIM ON FRONT OF FRONT SEAT

05-18-10
BRAKE NOISE - VEHICLES BUILT BEFORE 3/8/2005
05-16-12
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS
05-15-13
FRONT SIDE MARKER LAMP RETAINING TAB BREAKING
05-15-12
FUEL FILL SLOW, OR DIFFICULT TO FILL - VEHICLES BUILT BEFORE
4/26/2005
05-15-8
TICKING AND/OR KNOCKING NOISE FROM ENGINE - 4.6L/5.4L 3V
05-15-2
GROWL/GRINDING NOISE IN 2ND OR 3RD GEAR DURING DECELERATION - TR3650 MANUAL TRANSMISSION - VEHICLES BUILT BEFORE 2/21/2005
05-14-4
WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135 - VEHICLES BUILT 11/29/2004 AND PRIOR
05-10-19
INTERMITTENT CD PLAYER CONCERNS - AUDIO UNIT PROGRAMMABLE MODULE INSTALLATION (PMI) REQUIREMENTS
05-9-18
DISCHARGED BATTERY - CHARGING SERVICE TIPS

05-9-14
CONVERTIBLE TOP RAISE/LOWER INSTRUCTIONS
05-9-11
FRONT SUSPENSION POPPING NOISE WHILE TURNING RIGHT OR LEFT - VEHICLES BUILT BEFORE 4/8/2005
05-9-3
INTERIOR PLASTIC TRIM - PAINT-TO-MATCH AND REPAIR - INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

05-8-6
EXHAUST VIBRATION AT 850 RPM - 4.0L ENGINE AND AUTOMATIC TRANSMISSION
05-7-3
AXLE WHINE - VEHICLES BUILT THROUGH 11/15/2004

05-6-15
AIR BAG WARNING LAMP ON - DTC B1891 IN RESTRAINTS CONTROL MODULE OR LAMP FLASHES CODE 53 - VEHICLES BUILT BEFORE 10/02/2004
05-3-1
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)

04-26-22
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH MULTIPLE DIAGNOSTIC TROUBLE CODES (DTCS) P035X AND NO DRIVEABILITY SYMPTOMS - 4.6L 3V ENGINE
04-26-16
WELD BONDING PROCEDURE
04-24-20
LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS

04-24-14
GENERAL PCM PROGRAMMING PROCEDURES

04-24-5
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR
04-16-1
ENGINE MISFIRE OR ROUGH RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS
04-9-6
BODY - PAINT - IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT - ACID RAIN NEUTRALIZATION

Technical Service Bulletins
2006 MUSTANG UPDATED: 3-17-07

07-5-13
DISCHARGED BATTERIES - VEHICLES IN STORAGE/LIMITED USAGE

07-5-8
BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS

07-4-3
LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE

07-3-9
MIL ON - DTC P0456

07-1-7
MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

06-26-2
CARPET REMOVE AND REPLACE

06-26-1
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

06-25-15
ALUMINUM BODY PANELS - CORROSION - SERVICE TIP

06-22-18
POWER WINDOW DIAGNOSIS

06-22-16
CONVERTIBLE TOP WEAR - BUILT BEFORE 10/11/2006

06-21-19
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

06-21-7
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

06-19-12
DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V

06-19-2
8.8 LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS

06-18-16
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP

06-17-8
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS

06-15-8
KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY

06-14-3
AIR CONDITIONER COMPRESSOR CLUTCH FAILURE - REVISED COMPRESSOR CLUTCH

06-12-11
LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS

06-10-13
MIL P0463 OR ERRATIC FUEL GAUGE

06-10-10
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

06-10-5
5R55S - TRANSMISSION FLUID LEAK

06-10-1
AIR CONDITIONER COMPRESSOR CLUTCH FAILURE - REVISED COMPRESSOR CLUTCH

06-9-11
LOUD TICKING NOISE - 3-VALVE ENGINES - STUCK LASH ADJUSTER

06-9-9
HESITATION ON ACCELERATION AFTER LONG CRUISE

06-7-10
MIL ON WITH DTC P2004 THROUGH P2008, P151A, P2015, P2020 - 4.6L 3V

06-5-4
PARK BRAKE CABLE FREEZING/REAR BRAKES DRAGGING

06-4-2
BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS

06-4-1
RATTLE/NOISE FROM THE CENTER STACK (RADIO/HEATER) OF THE INSTRUMENT PANEL OR GEARSHIFT AREA

06-3-13
FUEL FILL SLOW, OR DIFFICULT TO FILL

06-2-9
DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V

06-1-5
DTC P1000 MAY NOT CLEAR IN HIGH ALTITUDE CONDITIONS

05-24-6
CONVERTIBLE SYSTEM CONCERNS

05-22-8
WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING

05-20-2
REAR AXLE NOISE

05-18-7
WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS

05-16-12
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS

05-9-18
DISCHARGED BATTERY - CHARGING SERVICE TIPS

07-6-7
SPOILER/DECK LID CONTACT

07-5-13
DISCHARGED BATTERIES - VEHICLES IN STORAGE/LIMITED USAGE

07-5-8
BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS

07-4-3
LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE

07-1-7
MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

06-26-2
CARPET REMOVE AND REPLACE

06-26-1
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

06-25-15
ALUMINUM BODY PANELS - CORROSION - SERVICE TIP

06-25-3
PIONEER NAVIGATION RADIO - SEEK FUNCTION INOPERATIVE - SERVICE TIP

06-22-18
POWER WINDOW DIAGNOSIS

06-22-16
CONVERTIBLE TOP WEAR - BUILT BEFORE 10/11/2006

06-21-19
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

06-21-7
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

06-19-2
8.8 LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS

06-17-8
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS

46-3v-01
LACK OF ACCELERATION - REPLACE ENGINE WITH MODULAR 5.0L DOHC CRATE UNIT :D

:lol:

:werd:

hahaha, NICE!!